HYDROKOAT 16 FOR AUTOMATED SPRAYING BOOTHS AND TUNNELS
HYDROKOAT 16 is a fungicide and insecticide microemulsion specially formulated for automated spraying booths and tunnels. HYDROKOAT 16 protects structural frameworks, roof trusses, panels, beams, joists and cladding – timber covered by a roof that is not in contact with the ground.
Free from propiconazole
Propiconazole is a reproductive toxicant in the 1B category of CMR chemicals
HYDROKOAT 16 provides wood for use class 1 and 2 with immediate protection which lasts for a minimum of 10 years when applied correctly.
HYDROKOAT 16 has CTB-P+ quality certification from the FCBA.
The efficacy of HYDROKOAT 16 has been tested and classified in line with European standards NF EN 599, NF EN 335 and NF EN 351.
HYDROKOAT 16 can be used for wood and timber CE marking.
DIRECTIONS FOR USE
HYDROKOAT 16 is sprayed onto the timbers in an automated spraying booth or tunnel.
HYDROKOAT 16’s specially adapted formula significantly reduces foam caused by pumping, which in turn reduces downtime for automated spraying booths and tunnels.
Apply HDROKOAT 6 to all the surfaces of each timber by separating the timbers before treatment using short, pre-treated planks
Do not apply at temperatures of 0°C or below as this prevents HYDROKOAT 16 from penetrating into the wood
Stir before use, especially if temperatures previously dropped below 0°C
Leave the wood to drain in a waterproof area
Leave the wood to dry in a sheltered area for 24 hours
Do not mix HYDROKOAT 16 with other wood treatments. Contact us for advice.
Spray cuts and nicks in the wood a second time
Clean spraying tunnels and booths regularly to make sure that they are free from wood dust and other contaminants
HYDROKOAT 16 complies with the following standards:
EN 46: Determination of the preventive action against recently hatched larvae of Hylotrupes bajulus (Linnaeus).
EN 113: Test method for determining the protective effectiveness against wood destroying basidiomycetes.
The long-term effectiveness of the insecticide and fungicide were tested further to the following accelerated ageing procedures:
EN 73: Evaporative ageing procedure
EN 84: Leaching procedure
For professional use only
HANDLE BIOCIDES WITH CARE
READ THE LABEL AND PRODUCT INFORMATION BEFORE USE
FOLLOW INSTRUCTIONS CAREFULLY
PACKAGINGVat: 200 kg
Dilution : 8% per volume of water
8 kg of concentrate with 92 l of water
PROPERTIESDensity: 1 = 20°C (+/- 0.03)
Flashpoint: not applicable
Fungicide: quaternary ammoniums
15-20 l/m3 depending on the size of the cross section of the wood